Term
| Normal operating water temp? |
|
Definition
|
|
Term
|
Definition
|
|
Term
|
Definition
|
|
Term
|
Definition
| Less than 140*F & 212*F and above. |
|
|
Term
|
Definition
|
|
Term
|
Definition
|
|
Term
| What is the Jabsco raw water pump rated at? |
|
Definition
|
|
Term
| At what temperature does the raw water system begine to cool the reduction gear? |
|
Definition
|
|
Term
| How much heat does the after-cooler remove from the air before it enters the combustion chamber. |
|
Definition
|
|
Term
| At what degree does the thermostate open to the jacket water expansion tank? |
|
Definition
|
|
Term
At what pressure will the oil
pressure releif valve open? |
|
Definition
|
|
Term
| What is the Oil Filter rated at? |
|
Definition
|
|
Term
| At what pressure will the oil filter be by-passed? |
|
Definition
|
|
Term
| At what pressure will the oil cooler be by-passed? |
|
Definition
|
|
Term
| How much psi does the blower generate? |
|
Definition
|
|
Term
| What cools the ECM and at what degree? |
|
Definition
|
|
Term
| How many inches is the fuel sucked off from the bottom of the fuel tank? |
|
Definition
|
|
Term
| What are the parameters of the fuel tank? |
|
Definition
394 Gallons @ 100%
373 Gallons @ 95% |
|
|
Term
| What is the Primary fuel filter rated at? |
|
Definition
|
|
Term
| What is the fuel pumps internal pressure reliefe valve? |
|
Definition
|
|
Term
| Secondary fuel filter is rated at? |
|
Definition
|
|
Term
| How much Fuel is returned back to the tank? |
|
Definition
|
|
Term
| What size is the fuel oil restricted orfice and what does it do? |
|
Definition
| 0.080" It provides constant back pressure to the system. |
|
|
Term
| What is the fuel oil pressure releife valve after the primary fuel filter set at? |
|
Definition
|
|
Term
| What type of Hydraulic fluid is used? |
|
Definition
|
|
Term
| What is the head pressure of the hydraulic reservoir? |
|
Definition
|
|
Term
| What is the hydraulic fluid filter rated at? |
|
Definition
|
|
Term
| What is the make and model of ther reduction gear and what is the ratio forward and reverse? |
|
Definition
Reinjes WVS 234 UP
2:1 ratio |
|
|
Term
| What is the diameter of the shaft" |
|
Definition
|
|
Term
| AT WHAT DEGREE WILL THE HIGH OIL TEMP ALRM SOUND FOR THE REDUCTION GEARS |
|
Definition
|
|
Term
| FOR EVERY 10 DEGREES OF TEMPERATURE ABOVE 90 DEGREES THERE IS A LOSS OF WHAT PERCENT IN HORSEPOWER |
|
Definition
|
|
Term
| HOW LONG WILL THE MDE RUN FOR AFTER PULLING THE EMERGENCY FUEL SHUT OFF VALVES AT FULL THROTTLE AND AT IDLE |
|
Definition
| 30 SECONDS AT FULL THROTTLE AND 5 MINUTES AT IDLE |
|
|
Term
| HOW MANY GPM DOES THE JACKET WATER PUMP? |
|
Definition
|
|
Term
| HOW MANY GPM IS THE OIL PUMP RATED AT |
|
Definition
|
|
Term
| AT WHAT TEMPERATURE DOES THE THE LUBE OIL COOLER MAINTAIN OIL |
|
Definition
|
|
Term
| HOW MUCH FUEL IS UNUSABLE |
|
Definition
|
|
Term
| WHAT KIND OF OIL AND WHAT CAPACITY IS MAINTAINED IN THE REDUCTION GEARS |
|
Definition
| 7.1 GALLONS OF 30 WT NON DETERGENT |
|
|
Term
| Normal operating temp for red gears? |
|
Definition
|
|
Term
| AT WHAT TEMPERATURE DOES THE CHECK ENGINE ALARM GO OFF? |
|
Definition
|
|
Term
| IF OPERATING THE "COME HOME" FEATURE FOR THE RED GEAR, WHAT IS THE MAXIMUM ALLOWABLE SPEED? |
|
Definition
|
|
Term
| AT WHAT TEMPERATURE WILL THE SMOKE/HEAT DETECTOR IN THE ENGINE ROOM GO OFF? |
|
Definition
|
|
Term
| What is the Fuel capacity of the CG-P6 and how high do you fill it? |
|
Definition
| 2.5 Gal of Gasoline. Fuel level should be two inches below the top. |
|
|
Term
| What type and how long is the line used to secure the CG-P6 instruction card to the explosion-proof flashlight? |
|
Definition
|
|
Term
| How many 2x3 inch pieces of reflective tape are required on the CG-P6 pump can and how are they placed? |
|
Definition
| 12 pieces of reflective tape. 4 pieces on the container lid equally spaced around the circumference. 4 pieces on the container side, 2 inches below the lid, equally spaced around the circumference. 4 pieces on the container bottom equally spaced around the circumference. |
|
|
Term
| How is the CG-P6 pump can lid labeled? |
|
Definition
| "NO SMOKING GASOLINE IN CAN" 3 inch black lettering. |
|
|
Term
| How is the CG-P6 pump container labeled? |
|
Definition
| "PROPERTY OF US COAST GUARD" 3 inch black lettering. |
|
|
Term
| What knot is used at the bitter end of the spare starter rope for the P6? |
|
Definition
|
|
Term
| What knot is used to secure the spare starter rope to the CG-P6? |
|
Definition
|
|
Term
| What knots are used on the 24inch type 1 nylon cord used to secure the CG-P6 instruction card to the explosion-proof flashlight? |
|
Definition
| Bowline followed by an overhand knot on each side of the 24 inch nylon cord. |
|
|
Term
| How long is the CG-P6 suction hose? |
|
Definition
|
|
Term
| How long is the CG-P6 discharge hose? |
|
Definition
|
|
Term
| CG-P6 engines that require more than ___ pulls to start shall be servived to achieve starts in less than ___ pulls. |
|
Definition
|
|
Term
| When should you fill a CG-P6 fuel tank? |
|
Definition
| When tank drops belowe 3/4 full. |
|
|
Term
| What is the RPM range of the CG-P6? |
|
Definition
| 1400RPMs at idle to 3900RPMs at full throttle. |
|
|
Term
| How long will the CG-P6 run at full throttle before running out of fuel? |
|
Definition
|
|
Term
| What is the horse power of the CG-P6? |
|
Definition
|
|
Term
| How much water does the CG-P6 pump? |
|
Definition
| At full throttle, the pump is capable of delivering over 250 gallons per minute at a 12' suction lift. NOTE: Higher discharge rates will be achieved at lower suction lifts. |
|
|
Term
| How long will the CG-P6 run at full throttle after disconnecting the fuel tank? |
|
Definition
|
|
Term
|
Definition
|
|
Term
|
Definition
|
|
Term
| What is the boats freeboard? |
|
Definition
Bow: 6'8"
Amisdships (Deck Recess): 2'2"
Aft: 7'1" |
|
|
Term
|
Definition
|
|
Term
| What is the highest fixed point? |
|
Definition
|
|
Term
| What is the highest unfixed point? |
|
Definition
|
|
Term
| What type of propellers are used? |
|
Definition
| Fixed 4 bladded, 28" diameter, 36" pitch. |
|
|
Term
| What is the displacement of the 47 MLB? |
|
Definition
| 40,000lbs (boat, full fuel, outfit; no crew or cargo) |
|
|
Term
|
Definition
|
|
Term
| Maximum personnel(including crew) |
|
Definition
|
|
Term
| Maximum Seas and Maximum Breaking Surf? |
|
Definition
| 30'Seas and 20' Breaking Surf |
|
|
Term
|
Definition
|
|
Term
| Range? (Cruising RPM in Calm Water) |
|
Definition
|
|
Term
| Maximum Operating Distance from Shore? |
|
Definition
|
|
Term
|
Definition
|
|
Term
| what is cruising speed and at what RPM? |
|
Definition
|
|
Term
| What is the Towing Capacity with the 3 1/4" towline? |
|
Definition
|
|
Term
| What is the Towing capacity with the 2" towline? |
|
Definition
|
|
Term
| What is the Ice Breaking Capability? |
|
Definition
|
|
Term
| What type of material is the boat made of? |
|
Definition
|
|
Term
| What type of hull design is the 47 MLB? |
|
Definition
|
|
Term
| How deep is the draft and what is it? |
|
Definition
| The propeller shaft strut extensions @ 4'6" |
|
|
Term
| The propulsion system is a _______ configuration? |
|
Definition
|
|
Term
| Between what frams does the propeller shaft penetrate the hull? |
|
Definition
|
|
Term
| How thick is the bottom platting? |
|
Definition
|
|
Term
| How thick is the side shell? |
|
Definition
|
|
Term
|
Definition
|
|
Term
| Where does the survivors compartment sink discharge? |
|
Definition
| Overboard port side at frame 5, just below and aft of the recess step. |
|
|
Term
| How is the forward peak ventilated? |
|
Definition
|
|
Term
| How do you check the red gear oil? |
|
Definition
| The reduction gear must be checked at low idle and must be between the L and H marks. (47 MLB manual Chapter 6 Section A.1. Pre-Start) |
|
|
Term
| Red. Gear Pressure Engaged and Disengages |
|
Definition
Engaged: 230-290
Disengaged: 58-66 |
|
|
Term
| What are the primary responsibilities of the 47' MLB Engineer? |
|
Definition
| Operational and underway maintenance of the propulsion and auxiliary systems. |
|
|
Term
| What is the bildge pump rated at? |
|
Definition
|
|
Term
| What happens when the engine(s) have been in an overload condition for more than one minute? |
|
Definition
| The EDM(s) will give an audible alarm and display "Code 410, Overload Warning." This will be deplayed for two minutes. If no action is taken for two minutes, the EDM(s) wll then display "Code 58, Torgue Overload," and the engine output will automatically ramp down to the maximum allowed power curve. |
|
|
Term
|
Definition
|
|
Term
|
Definition
|
|
Term
|
Definition
|
|
Term
|
Definition
| ECM Battery Low (low voltage alarm) |
|
|
